Difference between revisions of "Inventory"
From SSS Wiki
Jump to navigationJump to search (→In red container:) |
(→In red container:) |
||
| Line 47: | Line 47: | ||
*Electric welder | *Electric welder | ||
*Length of scaffold pipe marked with black tape for tightening winch drum nuts | *Length of scaffold pipe marked with black tape for tightening winch drum nuts | ||
| − | *Air compressor - | + | *Air compressor - Please RTFM [[Rhyas compressor.pdf]] - '''NB: Check oil level is up to red mark before use - SAE30 oil. The duty cycle is 50% on 15 minute continuous running. I.e. it should be not run on load for more than 15 minutes and then it must be given 15 minutes to cool down.''' |
*Air Impact Wrench - '''NB: when tightening nuts and bolts with this tool note that it is powerful enough to over stress most of them, so use low pressure to run up nuts/bolts and finish off with a torque wrench.''' <br>See instructions [[Media:Air impact wrench.pdf]] [[Media:Impact_pts_list.pdf]] Needs a minimum pressure of 90 psi <br>There is also a set of 3/4" > 1/2" > 3/8" reducing socket drivers. USE WITH CARE. | *Air Impact Wrench - '''NB: when tightening nuts and bolts with this tool note that it is powerful enough to over stress most of them, so use low pressure to run up nuts/bolts and finish off with a torque wrench.''' <br>See instructions [[Media:Air impact wrench.pdf]] [[Media:Impact_pts_list.pdf]] Needs a minimum pressure of 90 psi <br>There is also a set of 3/4" > 1/2" > 3/8" reducing socket drivers. USE WITH CARE. | ||
*20 metre air hose | *20 metre air hose | ||
Revision as of 13:35, 31 December 2014
Fluids and lubricants
In vehicle container:
- Antifreeze 25 litre
- Auto transmission fluid 25 litre
- Axle oil EP80/90 25 litre
In red container:
- Engine oil 20W/30 for Leading generator
In generator house
- Engine oil 200 litre drum
- Antifreeze 25 litre (30% solution)
Special Tools
In winch shelter
- Gantry crane
With Equipment Officer
- 150 piece socket set
In vehicle container
- Crowbars for re-setting winch guillotines
In club house
- Step ladder
In hangar
- Extending ladder
In red container:
- 2 tonne vehicle jack
- Axle stands
- Car ramps
- Electric welder
- Length of scaffold pipe marked with black tape for tightening winch drum nuts
- Air compressor - Please RTFM Rhyas compressor.pdf - NB: Check oil level is up to red mark before use - SAE30 oil. The duty cycle is 50% on 15 minute continuous running. I.e. it should be not run on load for more than 15 minutes and then it must be given 15 minutes to cool down.
- Air Impact Wrench - NB: when tightening nuts and bolts with this tool note that it is powerful enough to over stress most of them, so use low pressure to run up nuts/bolts and finish off with a torque wrench.
See instructions Media:Air impact wrench.pdf Media:Impact_pts_list.pdf Needs a minimum pressure of 90 psi
There is also a set of 3/4" > 1/2" > 3/8" reducing socket drivers. USE WITH CARE. - 20 metre air hose
- air line tyre inflator
- Wood saw
- Circlip pliers
- Case opener (crowbar) 2 off
- Spare filters
- Lubricants and sealants
- Jug and funnel for topping up auto gearboxes
Ground maintenance:
- Shovel
- Spade
- Fork
- Pickaxe
- Lawn mowers
Yellow tool box contents:
- Nuts, bolts and washers various
- Battery SG tester
- Ear defenders and safety goggles
- Compression tester
- Socket and bar for tightening winch half shaft nuts
- 27mm impact socket for drum nuts
- Compression gauge
- Multimeter
- Circlip pliers
- Rivet snap
- Electric drill
Spares
All sorts of useful lumps
